Product ID:BUTYL SEALANT
MSDS Date:01/01/1989
FSC:8030
NIIN:00N049806
MSDS Number: BVDKW

TREMCO

3735 GREEN RD
BEACHWOOD, OH 44122
US

Emergency Phone: 216-786-6727;800-424-9300(CHEMTREC)

Info Phone: 216-292-5000

Cage: TRMC0

TREMCO INC

CLEVELAND, OH 44128 US

Telephone: 216-752-4400

Cage: 94529

<15(WT).

RTECS: 9999999ZZ

FETOTOXICITY OCCURRED IN PREGNANT RATS EXPOSED BY

RTECS: 9999999ZZ

CALCIUM CARBONATE

CAS: 1317-65-3

RTECS: EV9580000

Fraction By Weight: 55%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

TALC

CAS: 14807-96-6

RTECS: MW2700000

Fraction By Weight: 10%

OSHA PEL 0.2 FIBERS;CC

ACGIH TLV: 0.2 FIBERS;CC

STODDARD SOLVENT; (MINERAL SPIRITS)

CAS: 8052-41-3

RTECS: WJ8925000

Fraction By Weight: 10-30%

OSHA PEL 500 PPM

ACGIH TLV: 100 PPM

TITANIUM OXIDE; (TITANIUM DIOXIDE)

CAS: 13463-67-7

RTECS: XR2275000

Fraction By Weight: 5-10%

OSHA PEL 15 MG/M3 TDUST

ACGIH TLV: 10 MG/M3 TDUST

XYLENE

CAS: 1330-20-7

RTECS: ZE2100000

Fraction By Weight: 20%

OSHA PEL 100 PPM;150 STEL

ACGIH TLV: 100 PPM;150 STEL

EPA Report Quantity: 1000 LBS

DOT Report Quantity: 1000 LBS

SILICA, CRYSTALLINE - QUARTZ

CAS: 14808-60-7

RTECS: VV7330000

Fraction By Weight: 0.2%

OSHA PEL N/K

ACGIH TLV: 0.1 MG/M3 RDUST

PROD IS ENCAPSULATED & REL IS NOT EXPECTED UNLESS IT

RTECS: 9999999ZZ

OVEREXP TO MINERAL SPIRITS CAN ADVERSELY AFFECT LUNG,

RTECS: 9999999ZZ

DAM IN MALE RATS, BUT NOT IN FEMALES/MICE. STUDIES

RTECS: 9999999ZZ

OVEREXP TO XYLENE CAN ADVERSELY AFFECT CNS, HEART,

RTECS: 9999999ZZ

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:YES IARC:YES OSHA:NO
Health Hazards Acute and Chronic:ACUTE: EYE: CAN CAUSE IRRIT. SKIN: CAN
CAUSE IRRIT, DERM. SKIN ABSORP: NOT ESTABLISHED. INHAL: CAN CAUSE
HDCH, DIZZ, IRRIT TO RESP SYS. INGEST: CAN CAUSE GI IRRIT. CHRONIC:
REPORTS HAVE ASSOC RPTD & P RLNGD OCCUP OVEREXP TO SOLV W/PERM
BRAIN & NERV SYS DAM. INTENTIONAL MISUSE BY DELIB CONC & INHALING
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:SILICA, CRYSTALLINE-QUARTZ: IARC MONO,
SUPP, VOL 7, PG 341, 1987: GRP 2A. NTP 6TH ANNUAL REPORT ON CARCIN,
1991:(SUPDAT)
Effects of Overexposure:HLTH HAZ: CONTENTS MAY BE HARMFUL/FATAL. THERE
ARE RPORTS THAT TALC MAY CAUSE PULM DAM AFTER 10-40 YRS OF OCCUP
OVEREXP W/OUT IMPAIRMENT IN LUNG FUNC; HOWEVER REL OF TALC FROM
PROD IS UNLIKELY UNDER N ORM CNDTNS OF USE. IARC CONCLUDED THAT
THERE IS SUFF EVIDENCE FOR CARCIN OF CRYSTALLINE SILICA IN
EXPERIMENTAL (SUPDAT)
Medical Cond Aggravated by Exposure:NOT ESTABLISHED.

First Aid:SKIN: WASH AREAS OF CONT THORO W/HAND CLEANER FOLLOWED BY
SOAP & WATER. IF IRRIT RASH/OTHER DISORDERS DEVELOP, GET MED ATTN
IMMED. EYES: FLUSH IMMED WITH RUNNING WATER FOR @ LST 15 MIN,
LIFTING LIDS O CCAS. GET MED ATTN IMMED. INGEST: GET MED ATTN
IMMED. INHAL: LEAVE AREA TO BREATHE FRESH AIR. AVOID FURTHER
OVEREXP. IF SYMPS PERSISTS, GET MED ATTN IMMED.

Extinguishing Media:IF WATER FOG IS INEFFECTIVE, USE CARBON DIOXIDE,
DRY CHEMICAL/FOAM.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA AND FULL
PROTECTIVE EQUIPMENT .
Unusual Fire/Explosion Hazard:NEVER USE WELDING/CUTTING TORCH ON/NEAR
CONTR (EVEN EMPTY). PROD, RESIDUE/VAP MAY IGNITE.

Spill Release Procedures:REMOVE SOURCES OF IGNIT IMMED. VENT TO REDUCE
AIRBORNE CONTAM CONC BELOW TLV. ABSORB SPILL IN SAND, EARTH/OTHER
SUITABLE MATL. TRANSFER TO APPROPRIATE CONTR FOR DISPOSAL.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE UNDER NORM WAREHOUSE CNDTNS
BELOW 80F. PVNT INHAL OF VAP, INGEST & CONT W/SKIN & EYES. KEEP
CONTR CLSD WHEN NOT IN USE.
Other Precautions:PRECAUTIONS ALSO APPLY TO EMPTIED CONTRS. PERSONAL
PROT EQUIP MUST BE WORN DURING MAINT OR REPAIR OF CONTAMD MIXER,
REACTOR OR OTHER EQUIP.

Respiratory Protection:USE APPROP NIOSH/MSHA APPRVD RESP WHEN AIRBORNE
CONTAM LEVEL(S) EXCEED TLV. FOLLOW MFR'S DIRECTIONS FOR RESPIRATOR
USE.
Ventilation:USE LOC EXHST WHEN GENERAL VENTILATION IS NOT SUFFICIENT TO
KEEP AIRBORNE CONTAM CONC BELOW TLV.
Protective Gloves:IMPERVIOUS RUBBER GLOVES.
Eye Protection:ANSI APPRVD CHEM WORKERS GOGGS .
Other Protective Equipment:TYPICAL FULL COVER CLOTHING.
Work Hygienic Practices:CHANGE SOILED WORK CLOTHES FREQUENTLY. CLEAN
HANDS THOROUGHLY AFTER HANDLING.
Supplemental Safety and Health
EXPLAN OF CARCIN: ANTIC TO BE CARCIN. EFTS OF OVEREXP: ANIMALS, BUT
ONLY LIM EVIDENCE IN HUMANS. PRLNGD & RPTD OVEREXP TO FREE SILION
DIOXIDE (SILICA) DUST ABOVE TLV LEVEL MAY CAUSE SCARRING OF LUNGS
W/COUGH & SHORT OF BRTH. A DELAYED LUNGINJURY, SILICOSIS MAY RSLT
FROM BRTHG FREE SILICA. HOWEVER, SILICA IN (ING 7)

Vapor Density:>1
Spec Gravity:1.57
Evaporation Rate & Reference:>1(ETHER=1)
Solubility in Water:NEGLIGIBLE
Appearance and Odor:PASTE; SOLVENT ODOR
Percent Volatiles by Volume:ING 12

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:NONE SPECIFIED BY MANUFACTURER.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.

Waste Disposal Methods:NOT REGULATED BY RCRA. DISPOSE OF IN COMPLIANCE
WITH STATE, FEDERAL AND LOCAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.